IEEE - ANSI C57.12.21
Requirements for Pad-Mounted, Compartmental-Type Self-Cooled, Single-Phase Distribution Transformers With High Voltage Bushings; High-Voltage, 34500 GRYD/19920 Volts and Below; Low-Voltage, 240/120 Volts; 167 kVA and Smaller
Organization: | IEEE |
Publication Date: | 1 January 1992 |
Status: | active |
Page Count: | 17 |
scope:
Foreward
The Accredited Standards Committee on Transformers, Regulators, and Reactors, C57, has for a number of years been developing and correlating standards on transformers and regulators. The data used in this work have been gathered from many sources, including the standards of the Institute of Electrical and Electronics Engineers and the National Electrical Manufacturers Association, reports of committees of the Edison Electric Institute, and others.
This standard was prepared by the Working Group of the Subcommittee on Distribution Transformers, Overhead and Pad-Mounted, C57.12.2, and is a revision of the 1986 edition. Added to this revision are sections on storage and installation with emphasis being placed on the actual position when stored and the consideration of the angle of tilt when installed.
Scope
This standard is intended for use as a basis for determining performance, interchangeability, and safety of the equipment covered, and to assist in the proper selection of such equipment.
This standard covers certain electrical, dimensional, and mechanical characteristics and takes into consideration certain safety features of single-phase, 60 Hz, mineral-oil-immersed
NOTE-Refer to latest federal regulations concerning polychlorinated biphenyl (PCB) contaminations in transformers.
This standard covers bushing and terminal arrangements for both radial and loop feed systems.
This standard does not cover the electrical and mechanical requirements of any accessory devices that may be supplied with the transformer.